Questions tagged [carrier]
The carrier tag has no usage guidance.
28
questions
0
votes
0
answers
35
views
Carrier Furnace Blower Motor Won't Run
Troubleshooting 25-yr old Carrier Furnace. Blower motor will not start. 24V at terminal strip (R and COM) on board. Checked all (4) limit switches; cleaned flame sensor and replaced igniter. Finally ...
0
votes
0
answers
96
views
How do you bypass the EIM on a Carrier unit?
I am in need of help installing Ecobee Premium on an existing Carrier unit. How do you bypass the EIM? Not sure what wires to use.
0
votes
2
answers
88
views
furnace not always turning on
I have a Carrier gas furnace.
For some reason, when I switch it on via thermostat, it SOMETIMES turns on, but SOMETIMES, it gets stubborn and refuses to turn on.
These are the symptoms:
When it's ...
1
vote
0
answers
351
views
Fault Code 41 on Carrier Infinity Heat Pump
Pardon the length but I know that if I don't cover it you all with just ask me anyway. ;-)
I had this Carrier Infinity system installed by Sears in 2009, IIRC:
Heat Pump: 25HNAB648A003
Air Handler: ...
0
votes
1
answer
81
views
Carrier HVAC System with Variable Speed Motor burned out after 6 months
I just recently purchased a Carrier Hvac 3 ton heat pump system back in February of this year. The heat pump has a variable speed fan that just burned out. Is this common? This is a new system and it ...
0
votes
1
answer
81
views
Is it ok that my furnace uses the air conditioner for dehumidification?
I have a Carrier 59mn7 furnace with an Infinity Thermo. The a/c condenser is a Ruud. The system does not have a dehumidifier installed--it is using the a/c during the dehumidifying function.
Is this ...
0
votes
1
answer
87
views
Hard vibrations (sometimes)
Can someone point me in the correct direction.
Once or twice a month my air conditioner unit (the one in te basement) will make a horrible vibration that can be heard throughout the house and I mean ...
25
votes
5
answers
5k
views
How can I protect a frozen heat pump in cold weather while waiting for service?
Yesterday I noticed that my Carrier heat pump was struggling to keep up with my thermostat settings inside the house. It was around 35°F (2°C) outside, I had the thermostat set at 72°F (22°C), but the ...
1
vote
2
answers
348
views
Carrier Comfort 80 Ignition Proving Failure
It's getting chilly here in California and I'm having an issue with keeping my Carrier furnace fired up.
I have a Carrier Comfort 80 Deluxe (Model# 58DLX070-08). When reset, the blower runs and fires ...
0
votes
1
answer
48
views
Attic Fan for Carrier 58STX110--14122
I have a Carrier furnace in my attic (Model 58STX110--14122). Does this unit include an attic fan? There is a fan that used to turn on during the day when it's hot and turns off when temperatures ...
0
votes
1
answer
2k
views
Help! Condensate pump is so loud and working when minisplit is off
Help! New homeowner here. We have a carrier minisplit in our bedroom, which works well. We live in a rowhouse (so two brick walls on the side), so a condensate pump is used to pump water onto the roof ...
1
vote
1
answer
284
views
Carrier Weathermaker 9200 Humidifier Ecobee blows 3amp fuse
I have a Carrier weathermaker 9200 with a bypass humidifier attached. I just moved into this house a year ago and the humidifier never worked with the humidistat. I tested the solenoid by putting a ...
2
votes
1
answer
176
views
Replacement HVAC blower motor fails within 24 hours?
My unit is a Carrier Infinity (FE4ANF003T00ABAA) with an ECM 3.0 blower motor.
To start, the thermostat reported a “Code 41 - Blower Motor Fault”. I ordered a refurbished motor + control module online ...
0
votes
0
answers
384
views
Carrier furnace blower doesn't kick up to high
I have two Carrier furnaces in my home. One is 100btu the other is 80btu they use the same the mother board. I have an outdoor wood boiler that heats our house and the furnaces are only use for back ...
2
votes
1
answer
1k
views
How do I temporarily remove a Côr WiFi thermostat by Carrier to repair a plaster wall?
The model number is TP-WEM01-A, installed with the "large backplate", as pictured below.
There are no visible screws, etc. I have the manual but it is no help.
1
vote
1
answer
1k
views
Connecting Carrier Infinity furnace to Aprilaire humidfier
I wish to replace my Carrier humidifier with an Aprilaire 700. I have 3 questions related to properly connecting my Carrier Infinity 96 furnace's HUM terminal to Aprilaire 700 (24 VAC line):
1) I see ...
0
votes
0
answers
62
views
hvac fan won't stop
My Hvac fan won't stop even after the desired heat is reached after the gas burning stops. I changed the furnace limit switch, no difference. Today I noticed there is an auxiliary limit switch on top ...
0
votes
1
answer
291
views
Carrier Furnace 58STX110-14122 fan starts the first time, but fails to start at subsequent calls for heat
On a Carrier Furnace model #58STX110-14122, when the initial call for heat comes on, everything works just fine in the following order:
Thermostat sends a call for heat
Draft Inducer motor kicks on
...
1
vote
1
answer
2k
views
Generac Generator with Carrier Infinity Heat Pumps
I've signed a contract to install a Generac 22.5 kW whole house generator and transfer switch in our home outside Boston.
Our home has Carrier Infinity 3 ton heat pumps installed on the first and ...
1
vote
0
answers
14k
views
Carrier Infinity System says "System Malfunction"
On this, the day temperatures reached 95, my AC stopped working. Here are the symptoms:
The thermostat says "Infinity System - System Malfunction Call Technician".
The condenser outside is spinning, ...
0
votes
1
answer
26k
views
MyInfinity thermostat dropping connection with Carrier server
My MyInfinity thermostat keeps randomly dropping connection carrier server. Wifi connectivity is stable (Arris TG1682g modem). Thermostat panel shows not connected to www.api.ing.carrier.com
...
3
votes
4
answers
3k
views
Inducer Fan Blowing Out Flames and Pilot Light on Carrier Furnace?
I have a Carrier furnace and have recently replaced the inducer fan assembly in it. The old motor assembly had a piece of sheet metal dangling under it; whereas, the new one does not.
The unit ...
1
vote
3
answers
6k
views
Old Carrier Furnace, 3-Wire Pilot Assembly, Electrode Sparks Continually While it Runs
Our 29 year-old Carrier furnace relies on a 3-wire pilot with an intermittent spark igniter. It sparks probably around 30 times before the gas valve opens and the furnace fires up. That's a lot of ...
0
votes
1
answer
2k
views
Low speed furnace fan blower motor will not shut off
I have a carrier furnace that has a low speed fan blower motor that will not shut off no matter how long I leave it running. I checked that removal of the G wire at the control board does not change ...
1
vote
0
answers
72
views
Carrier humidifier hookup
I had a blower replaced. In doing so, the technician pulled the wiring for the humidifier. The image shows the black wire is in place, the white wire not showing in the image is not wired in. Where ...
1
vote
0
answers
2k
views
How does one set the temperature threshold for heatpump? Carrier Infinity
I've just had a Carrier Infinity heat pump installed, with the matching smart thermostat. The only problem with it is that while it has three settings for the heat source:
Heat pump only
Electric ...
2
votes
1
answer
759
views
Carrier AC Air Handler Model #FC4DNF060 Filter Access Panel
I have a Carrier AC Air Handler Model #FC4DNF060. The filter access panel is blocked as shown in the photo (at bottom of unit). Has anyone had a similar situation or advice on how I might be able to ...
0
votes
1
answer
1k
views
Furnace sometimes fails to ignite, despite extensive replacement of parts
I posted a questions months ago, that it randomly decides to not start. Random as in work for a few hours, a few days, a few weeks....whenever it feels like not working, random. I went and replaced ...