The furnace is part of an HVAC or central heating system used to generate heat. Typically this is done with gas, a heat pump, or an electric element. For hot water and radiator based heating, use the boiler tag.

learn more… | top users | synonyms

2
votes
1answer
18 views

How do I determine/control which heat source is used (heat pump, oil)

I have a heat pump and an oil furnace for backup. How does the HVAC system know when to use the heat pump and when to use the oil furnace? Specifics: I have a Honeywell TH8320U1008 thermostat ...
0
votes
1answer
16 views

Which terminal should be used for a ā€œCā€ wire when none are labeled ā€œCā€? Older electric furnace/heat pump

I have an all electric air handler/furnace connected to a separate AC unit and it is also a heat pump. I've purchased the latest and greatest Honeywell WiFi "Smart" Thermostat and it needs a C wire. ...
0
votes
0answers
29 views

Furnace not working properly with digital thermostat

I have been attempting to use several different types of digital thermostats to replace my old mercury thermostat, however none of them are able to control the furnace properly. All of them are able ...
1
vote
1answer
14 views

Could a high limit switch cause the furnace blower to run continuously?

My furnace was running fine. The I noticed that the unit was blowing cold air. Checked the furnace burners and they were off. I turned off the unit on the thermostat and the blower continued to run. ...
1
vote
0answers
32 views

Why is my furnace blower running at low speed?

My Payne gas furnace (PG8UAA 42091) automatically shuts down after it lights and burns for two minutes. It then gives a 33 fault code. I've done some research and some testing and have narrowed the ...
0
votes
0answers
29 views

Furnace reset problem

I have a new Goodman high efficient furnace model number GMH950703BXAG1. And this is the problem I'm having now: Turn on the furnace power (after ~1 hour off) Turn on the thermostat with Temp ...
0
votes
0answers
23 views

Steps for annual maintenance on a fuel oil furnace?

We have fuel oil and this year I'd like to try and maintenance the furnace myself: By "maintenance" I mean "clean it up so that it runs well throughout the winter." Just a basic tuneup and ...
0
votes
1answer
60 views

Why does my oil-furnace's on-demand water heater go tepid and then return to full heat?

We have an issue with the hot water from a 2004 Peerless oil furnace with on-demand hot water. The shower starts at full temp, but quickly goes tepid (too cool for a bath/shower, but not ice-cold) and ...
0
votes
0answers
16 views

Which should I do first? replacing furnace or resurfacing concrete floor?

I'm going to get two things done in my basement soon (by hiring professionals), but I'm wondering what the right order of operations is. One task is to replace the gas furnace that sits near the ...
1
vote
1answer
76 views

Can I relocate my furnace exhaust?

When my new furnace was installed, the vent was put outside the house next to landscaping bushes. It has killed one of my bushes. It used to be vented up to my roof and out. Can I move this outside ...
0
votes
1answer
30 views

What could cause the blower in my furnace to come on?

Ok my blower just turned on, my propane furnace and it's not in operation due it being summer. My thermostat is set at 65 and the room temp is 78. The heater never actually fired it was only the ...
3
votes
2answers
645 views

Why would my Goodman gas furnace start but not stay on for more than 2-3 minutes?

I've got a problem with my 15 year old Goodman furnace. It starts w/o problem, inductor begins working, hot surface ignitor lights up and ignites the gas. Then the main blower starts working and the ...
7
votes
2answers
156 views

Why are furnace/central AC blowers so inefficient?

I can buy a ceiling fan from Home Depot capable of moving 5,000 CFM of air for about $50, and it uses a mere 50-60 watts while doing it. By contrast, most furnaces seem to have blowers that operate in ...
2
votes
1answer
45 views

Is it a problem that I have two of each color wires on my Honeywell thermostat?

I am thinking about upgrading my Honeywell thermostat. Every thing I have seen describes / shows a single wire for each color. My current thermostat has two wires connected to each terminal (two green ...
2
votes
3answers
8k views

How do I wire an old furnace motor so I can use it as a garage exhaust fan?

Since last I posted, I moved WAY south (lil warm down here) and the house I moved into was a foreclosure so a few things needed done, namely the AC and furnace. When the guy did the job he said he ...
7
votes
6answers
8k views

Where should my furnace filter go in a Lennox G40UHX series furnace?

I have a Lennox G40UH(X) series furnace, which is installed in our attic (We have a single-story house on a slab). Because the furnace is installed in the attic, it is "laying down" on its side, and ...
1
vote
2answers
3k views

Adding a C wire to a new Honeywell WIfi Thermostat

I am trying to install a new Honeywell touchscreen WIFI thermostat (http://www.homedepot.com/p/Honeywell-Wi-Fi-Smart-Thermostat-RTH9580WF/203926327?N=5yc1vZc5kl) and need to add a C wire to my ...
2
votes
2answers
4k views

How do I identify the C terminal on my HVAC?

How do I identify the C terminal on an HVAC, furnace, or boiler? If the terminals don't have a screw labeled C what should I look for on the wiring diagram? What steps should I take if a wiring ...
4
votes
3answers
2k views

Why does the pilot light go out when the furnace is running?

Every time the furnace fires up, it blows out the pilot light. Sometimes it will run a full cycle and blow out when it shuts down, and sometimes it will blow out about a minute into the cycle. We ...
4
votes
3answers
19k views

Which way does air flow into a furnace?

Which way does air typically flow in a furnace? Put another way, does the filter usually sit before the incoming cool air reaches the burners or after? I'm trying to figure out which way the air flow ...
2
votes
2answers
372 views

Are High End Furnace Filters worth the cost?

There are many levels of furnace filters. I can get cheap ones at walmart of a few bucks. Then there are ones that cost upwards of $30. I realize that if you have allergies or low immune systems, ...
4
votes
1answer
2k views

What would cause my furnace to only work with the filter removed?

My Carrier furnace works fine without the air filter in place on the return. With the filter in place it works for a while and then stops with a complaint about "limit, or flame rollout is open" ...
3
votes
2answers
2k views

What would cause a furnace to shut off prematurely?

I've got a Carrier Weathermaker 8000 furnace that shuts off about 90 seconds or so after ignition, started doing this recently. I get flashing code "33" which indicates: The code indicates: 33 ...
3
votes
2answers
380 views

What is this name of this vent attachment next to my furnace?

What is the name of this silver vent attachment thing at the bottom of the picture? It is attached to the side of our gas furnace. The black part is an insulated air duct which goes to a vent ...
2
votes
1answer
2k views

Why does my pilot light go out when I release the pilot light knob?

My furnace pilot light will not stay lit. I can light it and depress the pilot switch for 2 minutes. But, once I let go of the button, the pilot immediately goes out. Does my thermocouple need ...
0
votes
0answers
31 views

Why is my new high efficiency furnace blowing cold air sometimes?

Why does my new furnace high efficient Payne furnace blow cold air,not constantly but at least 3 different times in a day, my thermastat is set on auto but when the weather is cold outside it will ...
1
vote
0answers
57 views

Will a single ductless mini-split heat pump be able to distribute its air evenly throughout my ranch house?

I am in the middle of a deep energy retrofit of my house, and a quick-and-dirty online manual J calculation of the projected loads once my projects are completed shows an estimated heating and cooling ...
0
votes
1answer
32 views

Would a radiant barrier help stop this heat transfer?

Using my nifty thermal camera, I discovered that my furnace closet's combustion air duct (visible in this question) is getting really hot when the attic heats up, and then (being sheet metal) it ...
1
vote
1answer
55 views

Why does my Thermo Pride oil furnace need constant restarts?

We have a Thermo Pride oil furnace that requires frequent restarts to run. We just purchased the house and had the annual service/safety check completed as it was neglected for several years. When the ...
0
votes
1answer
30 views

Water has quit running thru my humidifier.

Furnace humidifier dry as a bone. have changed the filter, duh, that is the only thing I know how to do! Bottom line, there is no water running through it.
9
votes
9answers
11k views

Do thermostat-controlled, auto-adjust HVAC vents exist?

The residential forced-air HVAC systems I have seen are controlled by a single thermostat in one room. One has to manually adjust the vents in order to adjust the temperature in other rooms. Is ...
2
votes
1answer
95 views

Can I properly install Roxul mineral wool batts in a mostly-drywalled stud bay by pushing them up from below?

Using my nifty thermal camera, I discovered that my furnace closet's combustion air duct (visible in this question) is getting really hot when the attic heats up, and then (being sheet metal) it ...
0
votes
1answer
40 views

gas furnace pilot light is lit,,won't produce heat, making a clicking sound,,,

my gas furnace isn't producing heat the pilot light is on and it's making a clicking sound what can I do? I've tapped the flame rod.
7
votes
2answers
911 views

Should I insulate steam pipes in the basement?

I have a steam-radiator heating system. The furnace is in the (unfinished) basement, and the steam-carrying steel pipes spread out across the basement ceiling before going up into the rest of the ...
0
votes
3answers
23 views

Can't select some temperatures with the thermostat of my furnace

I have a problem with the thermostat of my furnace. This problem is wired but I'll try to explain it as clearly as possible. When I turn the button of the thermostat, some temperatures can't be ...
2
votes
2answers
106 views

What could be causing my gas furnace to make a loud noise?

I have a comfort air natural gas furnace when it call for heat,their is a loud boom noise,could the hot surface ignitor have a crack or needs replacing?
1
vote
2answers
71 views

How can I safely put a plug on an old furnace motor that has just two wires

My Old furnace motor has just 2 wires, Black and white. How can I safely put a plug on it to use it? I want it to power a chicken plucker.
2
votes
2answers
311 views

Should my furnace closet have this huge duct opening into the unconditioned vented attic?

So my interior furnace closet has a huge duct in it that connects the closet to the unconditioned vented attic right above it. Needless to say, this is a huge air leak into the conditioned part of the ...
0
votes
0answers
26 views

A/c runs while gas furnace is on

In the winter when gas furnace is turned on, a/c comes on preventing house from warming up. When disconnect is pulled at condenser, house is able to heat. Do not think that system is a heat pump. ...
0
votes
1answer
90 views

Running computers in basement storage room safely

I have kinda an odd one. I'm mostly concerned about fire safety here and am not concerned about power, I already know how to handle that properly. I have a somewhat large basement with an unfinished ...
0
votes
1answer
1k views

Gas furnace kicks on then off frequently

A few times in the past week I will wake up to my furnace turning on, hearing a click when it tries to ignite, then turn off. This will happen for a couple minutes before the furnace quits trying. ...
1
vote
0answers
92 views

How can I install a furnace register in a kitchen-cabinet toe kick?

I'm planning to install new kitchen cabinets. I'll be covering up the kitchen's existing sidewall diffuser with new cabinets, so I'd like to relocate it to a new register in the toe kick of the sink ...
0
votes
1answer
39 views

I have just reset furnace due to a trouble code, what should I monitor or re-do over the next few days?

My furnace was throwing a trouble code. The code was 31 and for my manufacturer (Bryant) and others thats is a pressure switch code. I was able to resolve this code and get my heat back on simply by ...
0
votes
2answers
85 views

Why does my furnace drip bucket fill up so frequently?

We have an oil furnace that heats the house using a two-zone hot-water circuit, and also acts as an on-demand hot water heater. There is a pipe coming off the collection of pipes coming out of it that ...
0
votes
1answer
67 views

How can I prevent my furnace exhaust pipe from freezing?

My furnace keeps on turning off because my air intake freezes. The reason it freezes up is because my neighbors exhaust vent blows directly on it. What can I do to prevent this?
0
votes
2answers
163 views

Would a failing igniter cause my furnace to blow cold air?

I noticed tonight my furnace was firing up, but not actually blowing out heat. I turned the thermostat down so it was no longer triggering it, let it sit for a couple of minutes, and then turned it ...
1
vote
1answer
195 views

Which way does the air flow through my furnace?

Below is my furnace and I need to change the filter however I am unsure which way is the airflow direction. Red or Blue?
0
votes
1answer
27 views

Furace fuse blows when Aprilaire humdifier is turned on above 35%

I live in a pretty old house and have a Carrier furnace with an Aprilaire humidifier attached to it. The device that controls the water flow, I guess it's a solenoid, is visible on the exterior of ...
2
votes
1answer
85 views

Is my Heat pump and gas furnace installation incorrect?

I moved into a house about 2.5 years ago, and the previous owners had a heat pump installed, together with a gas furnace. Recently I had my furnace repaired (faulty igniter) and the HVAC technician ...
2
votes
1answer
62 views

Is the furnace undersized?

I have a 2700 sq ft rambler home with cathedral ceilings over a large portion of it - over the hallway, 2 living rooms and kitchen. We replaced the furnace that was installed when the home was built ...