The furnace is part of an HVAC or central heating system used to generate heat. Typically this is done with gas, a heat pump, or an electric element. For hot water and radiator based heating, use the boiler tag.

learn more… | top users | synonyms

0
votes
0answers
58 views

Is the Thermostat controlling the wrong zone? (Multi-zone heating with gas furnace)

UPDATE 12-29-2015: I've poked around and found, what I believe is, the board controlling the zones (Trol-A-Temp Mini-zone). Before I make any changes there, I chose to replace the thermostat on the ...
0
votes
1answer
75 views

How to wire a C-wire from a humidifier to a Carrier furnace?

I need guidance on a wire. One wire connects the humidistat to HUM. Another wire should go from the humidifier to COM24Vac. My COM is taken as you see in the picture. Is it an issue to wire the second ...
4
votes
1answer
724 views

How many wires can be connected to the C terminal at the furnace?

I'd like install a new Wi-Fi thermostat. The old one didn't have a C-wire but luckily there is an unused wire on both sides (one coming out of the wall and one at the furnace not connected yet), so I ...
1
vote
2answers
49 views

Can I retrofit a 2-speed or variable speed blower on a Payne PG8UAA forced air furnace?

My furnace blower is rather loud and runs at one speed. I wish to have the blower run at a slower speed to mix the air in the house when the heat is not called for. I see some furnaces have ...
0
votes
0answers
37 views

Oil furnace fan timing, limit temp setting

I just installed a new Crown oil furnace and a two wire thermostat. The furnace fires up fine but the blower won't turn on until it shuts down and the high temp limit control takes over. Then the ...
0
votes
2answers
56 views

wiring in a electric furnace to electrical subpanel

I have a 30 amp double breaker in my main home panel feeding my detached garage 100amp sub panel. Can i run a electric furnace with a 90 amp breaker in the subpanel. Or is this setup all wrong
0
votes
2answers
91 views

Furnace fan works properly intermittently

My furnace fan sometimes stays on and runs continuously. I can stop it by flipping the breaker for the furnace on and off. It then stays off. When heat is called for, the fan comes on again and ...
0
votes
0answers
205 views

My furnace has a C - common wire but air conditioner uses it - how to hook up smart thermostat?

I bought an ecobee3 smart thermostat which requires the C wire. At my furnace there is no circuit board but there was a diagram and I was able to locate the C - common wire, but it seems to be used ...
0
votes
1answer
158 views

hooking up a humidifier on a carrier infinity furnace

Hello I would like to hook up my desert spring rotary disc humidifier to my new carrier infinity model #59MN7 furnace. I see the control board in the furnace has a HUM (humidifier) terminal and a ...
0
votes
0answers
48 views

new furnace hurts eardrums

I just got a new furnace in my 800 sq. ft apartment. Single stage 80% efficiency 40K BTU Coleman. It seems much louder than my old one. The burners and the blower. And when I walk past the (single) ...
3
votes
1answer
109 views

Furnace: are flames in between the tubes bad?

In a Carrier Weathermaker 8000 gas furnace, is it normal for some of the flames to be coming out of the spacers in between the tubes? It seems like they shouldn't be there, since they aren't going ...
1
vote
1answer
60 views

Actual efficiency of an old oil furnace?

We purchased a house with what appeared to be a relatively well-maintained oil furnace, about 30 years old (installed in 1984). We don't have any records of annual oil usage, or any way to find that ...
0
votes
1answer
43 views

question about a gas furnace having to light repeatedly

I am new to this forum, but I will do my best to answer any questions I can (I am a general contractor with a background in engineering and residential construction and machine design) so, here is my ...
0
votes
0answers
43 views

Furnace on the Fritz - Any help greatly appreciated

I have a Tran XL90 - Model #: TUX100R948W6 It does not turn on in the "Auto" position on the thermostat. The fan does come on in the "On" position. However, it doesn't blow hot air. It has 3 ...
0
votes
0answers
23 views

miller mobile home furnace

When I press the reset button my furnace turns on and goes what seems to be a complete cycle. At this time the heat comes from the register nice and strong. When it comes on the second time it shuts ...
2
votes
5answers
972 views

Low voltage fuse blowing in furnace

I have an outside A/C compressor and indoor furnace fan combo in the attic. The unit was off and the 3 amp fuse was blown. I replaced the fuse and used the thermostat to turn the fan on followed by ...
2
votes
1answer
39 views

0v at DC thermostat terminal in furnace

I have an old (mid 80s) Rheem gas furnace I hope will last me through at least one more California winter. It's been known to go down into the upper fifties, so it has its work cut out for it. In any ...
0
votes
1answer
61 views

Furnace Fuse Blows Immediately

This afternoon, our Ruud furnace suddenly stopped working. After poking around a bit, I realized that the 3A fuse on the control board had blown. I ran to the hardware store and replaced it, but no ...
0
votes
0answers
7 views

Can I use any C terminal on a furnace to supply power to a thermostat? [duplicate]

I have a dual heat system with a gas and electric plenum. trying to install a wifi thermostat and found that the C wire on the furnace is connected but once it goes up and through the electric plenum ...
0
votes
0answers
223 views

No C wire terminal on my electric plenum but there is on my furnace. How do I solve?

I had a brand new furnace installed recently but also now picked up a wifi thermostat. The problem I now encountered while installing the thermostat is that my system also has an electric plenum as ...
0
votes
0answers
59 views

wiring for rheem 2 stage furnace

I am trying to wire a Honeywell 2 stage thermostat to a Rheem classic 90 gas furnace. At the furnace there is a white wire with a red strand connected to the R post, a blue to the C, green to G, ...
0
votes
2answers
144 views

Rain water leaking around attic furnace

I bought a house a few months ago and when I bought it I noticed what appeared to be a water spot on the ceiling of the top floor. Of course I didn't do anything about it until heavy rains over the ...
3
votes
1answer
125 views

How does old wood furnace work?

My mother in law has an old wood furnace in her workshop. It obviously is different than the typical wood stove you see. Does anyone have one of these? Or can anyone explain the theory behind its ...
0
votes
1answer
379 views

Correct Wiring for Furnace Blower Motor

After getting my furnace blower motor replaced, it now runs only in the following scenarios: 1. Mode "Cool" Fan "Auto" 2. Mode "Cool" Fan "On" 3. Mode "Heat" Fan "On" In other words it will not run ...
0
votes
0answers
70 views

Need help with a Trane XR90 gas furnace not heating

Diagnostic blinking light is 3. Tried calling Trane with no returned call and its getting really cold tonight. 30 degrees. Help plese
3
votes
2answers
2k views

Hvac Fan only blows in 'fan on' mode while heating

Our HVAC Fan only blows in 'fan on' mode while heating. In other words the fan will not blow in heat mode if switched to "fan auto". Both fan on and fan auto modes work when cooling. See image below, ...
0
votes
2answers
69 views

Replace or wash this furnace filter?

My mom's furnace has ductwork until right next to the furnace, where the return air instead goes into an obsolete electronic air cleaner that is basically as big as the furnace itself. The issue is ...
0
votes
1answer
76 views

Cant I just use a 24v wall instead of a tranformer?

I can just use a 24v wall transformer that I have plugged into my sprinkler system and use that in place of the transformer on my electric Central coleman furnace right? I would connect the hot line ...
2
votes
1answer
243 views

What is the optimal duty cycle for a furnace?

A heat load calculation of my home says it requires ~36K BTU/hr of heat at a normal winter temperature (40°F), and ~52K BTU/hr at the design temperature (24°F). An HVAC contractor has proposed ...
0
votes
1answer
45 views

How do I switch the furnace to heat mode?

I have an older good Sears furnace. It was on cool mode this summer and the fan could come on. I can't find how to switch it back to heat mode! Thanks. Linda
9
votes
1answer
534 views

What does this device on my new furnace do?

Can someone please tell me what this is? I had a 35-year old oil furnace replaced recently and the new furnace is obviously more complex and has many safety features the old one didn't. I've looked it ...
1
vote
1answer
60 views

How do I compare furnace models?

I need a new furnace, and I have quotes from two companies, for three different brands of furnace, Carrier, Trane, and Lennox. Both companies have provided the model numbers of the units they would ...
0
votes
1answer
90 views

New Thermostat installed but compressor comes on immediately

I have a new Insteon Thermostat that I'm using to replace my prior Honeywell t-stat. This is installed to a relatively new HVAC system (both AC and Heat) that DOES have a "c" wire. I've attached the ...
0
votes
0answers
139 views

What makes a furnace pilot valve whistle?

I have a furnace that started whistling, recently. I have read that gas pressure changes can cause this. Others have remarked how seasonal gas changes can lead to a properly-adjusted furnace to ...
0
votes
2answers
249 views

My goodman furnace is not igniting my burners

I have a goodman furnace and when it is calling for heat the ignitor comes on and goes off and comes on again and the burners never comes on what could be the problem
1
vote
1answer
25 views

Central Furnace blower alwas on, even with thermostat disconected

A technician told me it was the electronic control board that has the blower relays on it , I replaced it and still has the problem, I've been reading here online about a limit switch for the blower ...
0
votes
1answer
84 views

Thermopride OL5-85 oil furnace no longer works

We bought this old house where the oil furnace worked for a while. Now it does not work even after adding enough oil and priming the furnace. We have already pushed the reset button..so I do not dare ...
0
votes
1answer
260 views

Furnace reaches temp, shuts off but wont come back on

I have an American Standard furnace (natural gas)with a manufacture date of 2004. The thing won't come on unless I power it off (have a switch right beside it that serves this purpose), let the fan ...
2
votes
1answer
36 views

What is required for seasonal maintenace of a heat pump?

Over the years I've had several local HVAC companies provide seasonal maintenance of the heat pumps and propane furnace in my house. It seems that every technician--even within the same company--does ...
2
votes
1answer
69 views

How can I improve the directional flow of my furnace exhaust pipe?

This one's for the creative folks. I'm in a condo on the top floor and I have a side neighbor. Both our furnaces exhaust out the back, under a four-foot roof section overhang (sticks out about a foot ...
0
votes
1answer
101 views

What is this 6" vent coming out of the main furnace trunk going under my deck for?

I have a 6 inch round duct that comes out of the main trunk about 5 feet from the furnace. It runs through the basement and outside the house (under the deck). What is this? The furnace also has 2" ...
0
votes
0answers
28 views

Whether to replace oil furnace with oil furnace and heat pump or convert to propane

I am in need of replacing my oil furnace and central A/C. My residence is in SW Wisconsin. I am confused as to whether or not to replace with an oil furnace and heat pump or to convert to propane ...
0
votes
1answer
44 views

Should there be a cap next to my furnace ac drain?

In the picture below, the left side has a good amount of airflow while the ac/blower is running. The tube on the right is the drain that the condensation flows out of to the floor. Should there be a ...
1
vote
1answer
53 views

Can using a new evap coil on top of an older furnace cause problems?

I am getting quotes for a new R410A condenser unit/evaporator coil from several HVAC contractors. A salesperson refused to give me a quote unless I purchase a new furnace as well. He said that he has ...
0
votes
0answers
47 views

Is this electric furnace likely to be insulated with asbestos?

I inherited this electric furnace and I'd like to identify the material it's made from. I've not managed to find any record online, but the company itself no longer exists. Given its vintage (90s ...
1
vote
1answer
371 views

Why would a blower motor work with A/C, but burn out with furnace?

I've gone through 2 blower motors since I purchased the home 3 yrs ago. I never have an issue with the blower when the AC runs; but it keeps dying in the winter with the furnace. I've had 2 HVAC ...
1
vote
1answer
39 views

What and how many appliance can share a room?

Can a central air gas furnace, gas dryer, electric washing machine, gas water heater be in same room (12x8ft) in the basement? dryer has its own vent to outside, Gas water heater, seems to use the ...
0
votes
0answers
47 views

C Wire is there, now where do I connect it?

So I'm purchasing a home but the thermostat is pretty old. I'd like to replace it with a Nest or something nicer. I've searched and searched but can't find where I would connect the C-Wire (it's ...
1
vote
0answers
23 views

What could cause the blower of a Coleman furnace to come on all by itself?

I have a Coleman furnace in my mobile home. It was really hot today and the furnace blower came on all by itself. It has ran for 7 hrs. and wont shut off. How do I fix this and what is the ...
4
votes
1answer
394 views

How bad is it to attach a gas water heater to a gas furnace electrical circuit?

I'm looking to replace my existing water heater with a more efficient model. One of the things that makes better models more efficient is the replacement of the thermocouple / pilot control system ...